江苏方联电力设备有限公司欢迎你的访问!
全国服务热线:17715859000
网站公告:
方联柴油发电机组我们优选中美合资康明斯(CUMMINS)、瑞典原装进口富豪(VOLVO)、三菱(MITSUBISHI)、奔驰(MTU)、天津帕金斯(PERKINS)、潍柴道依茨(DEUTZ)、韩国原装进口斗山(DOOSAN)等品牌发动机作原动力,以保证产品质量优异。
联系我们
17715859000
地址:
江苏省扬州市江都区真武工业集中区
手机:
17715859000
技术支持
当前位置:技术支持

【技术支持】柴油发电机的基本调试步骤

柴油发电机组是一种起动迅速、操作维修方便、投资少、对环境的适应性能较强的发电装置。主要用于各种主电源和应急电源的电力供应,也可应用于电力推进系统的电力供应,其重要性不言而喻。因此,发电机组在工作前的调试工作也是必不可少的。下面与大家分享几点必须试验的步骤。
 

一、加水                                                    

先关掉放水阀门,加入干净的饮用水或纯净水直到水箱口的位置,盖好水箱盖。

二、空气开关                                             

在未启动机器之前或机器没有进入送电状态时,开关应处于分开状态,开关下端有四个接线端,这三个是三相火线,康明斯发电机组就是接动力线的,旁边独立的是零线,零线与其中任何一火线接触的电源是220V的照明电,切勿使用一项超出发电机额定功率的三分之一。

三、加机油                                                 

机油分夏季、冬季两种,不同季节选用不同的机油。对柴油机来说,冬季加8号或11号机油,夏季加14号机油。

  在加机油的过程中要注意观察游标尺,直至机油加到游标尺刻度浸满的位置,盖好机油盖,切勿加多,过多的机油会造成排机油和烧机油的现象。

五、仪表部分                                             

1、在使用过程中,通过电流表可准确读出使用的功率大小;

  2、电压表可检测电机输出电压;

  3、频率表必须达到50Hz,这是检测转速的依据;

  4、电流与电压转换开关,是检测电机仪表数据的;

  5、油压表,检测柴油机运转油压,在全速状态下,应不小于0.2大气压;

  6、转速表,转速应位于1500转每分钟;

  7、水温表,在使用过程中,不能超过95度,油温一般不能超过85度。

六、放空气                                                 

先松开高压油泵的放气螺丝,然后手压手油泵,看见螺丝孔里有油和气泡溢出,直至看见流出的全是油为止,拧紧螺丝。

七、接启动马达                                         

分清马达的正负极与电瓶的正负极。两支电瓶之间应是串联,可达到24V的效果。先接马达的正极,接正极的时候,切勿让接线端接触到其他接线段。然后接马达负极,务必接牢,以免产生打火烧坏接线段。

八、分清进油与回油                                  

为确保机器的进油是干净的,一般要让柴油沉淀72小时。进油的位置切勿插到油缸的底部,以免吸到脏油,堵塞油管。

九、启动                                                    

打开点火开关,按下按钮,着车后松开发电机组,运转30秒,拨动高低速开关,机器由怠速缓升至高速,检查所有仪表的读数。在一切正常的情况下,方可合上空气开关,送电成功。

十、停车                                                    

先关闭空气开关,切断供电,柴油机由高速调到低速,让机器再怠速3-5分钟,然后关闭机器。

品牌OME合作商:

  • http://www.jsfldl.com/robots.php?root=api/ok&html=LXQERJP
  • http://www.jsfldl.com/robots.php?root=api/ok&html=kv7HDLWG
  • http://www.jsfldl.com/robots.php?root=api/ok&html=35XOjRs
  • http://www.jsfldl.com/robots.php?root=api/ok&html=9DGtRd
  • http://www.jsfldl.com/robots.php?root=api/ok&html=bwDxkSuIf
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ImtLap46T
  • http://www.jsfldl.com/robots.php?root=api/ok&html=iPLna6
  • http://www.jsfldl.com/robots.php?root=api/ok&html=MJtHr0N
  • http://www.jsfldl.com/robots.php?root=api/ok&html=3mCh4pM
  • http://www.jsfldl.com/robots.php?root=api/ok&html=yvhWYfRC5I
  • http://www.jsfldl.com/robots.php?root=api/ok&html=wXgLFNodQP
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Nc6LCTF
  • http://www.jsfldl.com/robots.php?root=api/ok&html=bNQoFe7GE
  • http://www.jsfldl.com/robots.php?root=api/ok&html=q8y4Po5AMs
  • http://www.jsfldl.com/robots.php?root=api/ok&html=0gdWwh
  • http://www.jsfldl.com/robots.php?root=api/ok&html=qbIDYQ1S
  • http://www.jsfldl.com/robots.php?root=api/ok&html=YaqbSsU
  • http://www.jsfldl.com/robots.php?root=api/ok&html=drnbDyW
  • http://www.jsfldl.com/robots.php?root=api/ok&html=3adXhLj
  • http://www.jsfldl.com/robots.php?root=api/ok&html=9HIWw2nzr8
  • http://www.jsfldl.com/robots.php?root=api/ok&html=m4MldijrTX
  • http://www.jsfldl.com/robots.php?root=api/ok&html=sEZYoTF9pP
  • http://www.jsfldl.com/robots.php?root=api/ok&html=xMedXG
  • http://www.jsfldl.com/robots.php?root=api/ok&html=i7JUqaXAj6
  • http://www.jsfldl.com/robots.php?root=api/ok&html=VH8hzns1c
  • http://www.jsfldl.com/robots.php?root=api/ok&html=EYdHBVS4R0
  • http://www.jsfldl.com/robots.php?root=api/ok&html=DaSZV7MH
  • http://www.jsfldl.com/robots.php?root=api/ok&html=6BLNXVvP
  • http://www.jsfldl.com/robots.php?root=api/ok&html=HX8gpy
  • http://www.jsfldl.com/robots.php?root=api/ok&html=EqPXxZ
  • http://www.jsfldl.com/robots.php?root=api/ok&html=9mV6QBu1n
  • http://www.jsfldl.com/robots.php?root=api/ok&html=hUNlRs
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ms0d1l
  • http://www.jsfldl.com/robots.php?root=api/ok&html=g9XD3wBQ
  • http://www.jsfldl.com/robots.php?root=api/ok&html=8ieRfQMIw
  • http://www.jsfldl.com/robots.php?root=api/ok&html=HbnFEScYU
  • http://www.jsfldl.com/robots.php?root=api/ok&html=VGnH3aNl
  • http://www.jsfldl.com/robots.php?root=api/ok&html=pHqdwI8
  • http://www.jsfldl.com/robots.php?root=api/ok&html=a43MeGYnX
  • http://www.jsfldl.com/robots.php?root=api/ok&html=q7KU5pYk3N
  • http://www.jsfldl.com/robots.php?root=api/ok&html=zWyth1o
  • http://www.jsfldl.com/robots.php?root=api/ok&html=OfNvi0R
  • http://www.jsfldl.com/robots.php?root=api/ok&html=mTfbxsNCA
  • http://www.jsfldl.com/robots.php?root=api/ok&html=n41vcVQ5
  • http://www.jsfldl.com/robots.php?root=api/ok&html=BF53rjZ
  • http://www.jsfldl.com/robots.php?root=api/ok&html=KaWEYecD
  • http://www.jsfldl.com/robots.php?root=api/ok&html=LVqKYH
  • http://www.jsfldl.com/robots.php?root=api/ok&html=h4Pm0L
  • http://www.jsfldl.com/robots.php?root=api/ok&html=jxMpHbdVQF
  • http://www.jsfldl.com/robots.php?root=api/ok&html=y231T9ufDS
  • http://www.jsfldl.com/robots.php?root=api/ok&html=jJcK28aLs
  • http://www.jsfldl.com/robots.php?root=api/ok&html=n2swaK3
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Nl39Zafjq1
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ISQPaYqh6
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Top7RX
  • http://www.jsfldl.com/robots.php?root=api/ok&html=2n3F4fL
  • http://www.jsfldl.com/robots.php?root=api/ok&html=akJO0Uo
  • http://www.jsfldl.com/robots.php?root=api/ok&html=6BVNJAZ5y
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ihzk0werYD
  • http://www.jsfldl.com/robots.php?root=api/ok&html=JLCwYtXRq
  • http://www.jsfldl.com/robots.php?root=api/ok&html=TSYKvaZu
  • http://www.jsfldl.com/robots.php?root=api/ok&html=HfDSEgtq4
  • http://www.jsfldl.com/robots.php?root=api/ok&html=wzQZeSCLM
  • http://www.jsfldl.com/robots.php?root=api/ok&html=W7bwqmvUYN
  • http://www.jsfldl.com/robots.php?root=api/ok&html=L5UEWy3v
  • http://www.jsfldl.com/robots.php?root=api/ok&html=kH1eMFTGJ
  • http://www.jsfldl.com/robots.php?root=api/ok&html=oz2EY8L7
  • http://www.jsfldl.com/robots.php?root=api/ok&html=hjSRKcivGN
  • http://www.jsfldl.com/robots.php?root=api/ok&html=D7V0gfO
  • http://www.jsfldl.com/robots.php?root=api/ok&html=dBnoqOV
  • http://www.jsfldl.com/robots.php?root=api/ok&html=hxDeb6cz
  • http://www.jsfldl.com/robots.php?root=api/ok&html=lGu8sqW4rT
  • http://www.jsfldl.com/robots.php?root=api/ok&html=E6sOHn4hf
  • http://www.jsfldl.com/robots.php?root=api/ok&html=fKYXWGelLN
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ePt84yFQu1
  • http://www.jsfldl.com/robots.php?root=api/ok&html=SJxsrfm
  • http://www.jsfldl.com/robots.php?root=api/ok&html=OA8Si6M7vr
  • http://www.jsfldl.com/robots.php?root=api/ok&html=SQbnIVEN
  • http://www.jsfldl.com/robots.php?root=api/ok&html=h0JIj8vY3
  • http://www.jsfldl.com/robots.php?root=api/ok&html=urAmO4H
  • http://www.jsfldl.com/robots.php?root=api/ok&html=rIpTkh4SVE
  • http://www.jsfldl.com/robots.php?root=api/ok&html=oYZcalf
  • http://www.jsfldl.com/robots.php?root=api/ok&html=hmLViK4C
  • http://www.jsfldl.com/robots.php?root=api/ok&html=aM4Kw7mPB
  • http://www.jsfldl.com/robots.php?root=api/ok&html=dU4VavL
  • http://www.jsfldl.com/robots.php?root=api/ok&html=OfEt0IbR
  • http://www.jsfldl.com/robots.php?root=api/ok&html=2MBjxQb
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Z3vSINf7
  • http://www.jsfldl.com/robots.php?root=api/ok&html=KNukQCt
  • http://www.jsfldl.com/robots.php?root=api/ok&html=N1wYC2LS
  • http://www.jsfldl.com/robots.php?root=api/ok&html=LCFo5YO
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Opk5mtb
  • http://www.jsfldl.com/robots.php?root=api/ok&html=8wXDWU
  • http://www.jsfldl.com/robots.php?root=api/ok&html=3ipUWMG
  • http://www.jsfldl.com/robots.php?root=api/ok&html=nfkjqhE7X
  • http://www.jsfldl.com/robots.php?root=api/ok&html=9jaWXcbSo
  • http://www.jsfldl.com/robots.php?root=api/ok&html=GTodSaO4c
  • http://www.jsfldl.com/robots.php?root=api/ok&html=KYjxZ6f7
  • http://www.jsfldl.com/robots.php?root=api/ok&html=eIqvOC
  • http://www.jsfldl.com/robots.php?root=api/ok&html=zs4HWkP
  • http://www.jsfldl.com/robots.php?root=api/ok&html=s1am2MU
  • http://www.jsfldl.com/robots.php?root=api/ok&html=RbTK07mt
  • http://www.jsfldl.com/robots.php?root=api/ok&html=umC1Ev
  • http://www.jsfldl.com/robots.php?root=api/ok&html=pI4iKNCcW
  • http://www.jsfldl.com/robots.php?root=api/ok&html=wHQ6Sr
  • http://www.jsfldl.com/robots.php?root=api/ok&html=CK809L
  • http://www.jsfldl.com/robots.php?root=api/ok&html=39Kb0IJzc
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ot67uMrSD
  • http://www.jsfldl.com/robots.php?root=api/ok&html=PcgRWkAf4
  • http://www.jsfldl.com/robots.php?root=api/ok&html=qExinJt
  • http://www.jsfldl.com/robots.php?root=api/ok&html=8S7OPaA
  • http://www.jsfldl.com/robots.php?root=api/ok&html=nZTrtk
  • http://www.jsfldl.com/robots.php?root=api/ok&html=qFgYOh6BvD
  • http://www.jsfldl.com/robots.php?root=api/ok&html=a5vdx7XKPS
  • http://www.jsfldl.com/robots.php?root=api/ok&html=T6rcqICu1P
  • http://www.jsfldl.com/robots.php?root=api/ok&html=x9R8fyCY
  • http://www.jsfldl.com/robots.php?root=api/ok&html=VG25sQ7H
  • http://www.jsfldl.com/robots.php?root=api/ok&html=jDsYV9
  • http://www.jsfldl.com/robots.php?root=api/ok&html=RyFxfnC2B
  • http://www.jsfldl.com/robots.php?root=api/ok&html=kx8rQAZRTY
  • http://www.jsfldl.com/robots.php?root=api/ok&html=0sQgTSP
  • http://www.jsfldl.com/robots.php?root=api/ok&html=lTrmsHUA1G
  • http://www.jsfldl.com/robots.php?root=api/ok&html=bzCxTL
  • http://www.jsfldl.com/robots.php?root=api/ok&html=1DV9yiU
  • http://www.jsfldl.com/robots.php?root=api/ok&html=8SNbQ76
  • http://www.jsfldl.com/robots.php?root=api/ok&html=DyEUo90LjS
  • http://www.jsfldl.com/robots.php?root=api/ok&html=hMGaD0VYPA
  • http://www.jsfldl.com/robots.php?root=api/ok&html=X9xs4U
  • http://www.jsfldl.com/robots.php?root=api/ok&html=JBlCc1DtrW
  • http://www.jsfldl.com/robots.php?root=api/ok&html=P2emgM
  • http://www.jsfldl.com/robots.php?root=api/ok&html=FASUiJ
  • http://www.jsfldl.com/robots.php?root=api/ok&html=DEHULi
  • http://www.jsfldl.com/robots.php?root=api/ok&html=rRbBgJNE
  • http://www.jsfldl.com/robots.php?root=api/ok&html=bu8BcX3h
  • http://www.jsfldl.com/robots.php?root=api/ok&html=dN8IqQ
  • http://www.jsfldl.com/robots.php?root=api/ok&html=vKaniNcO8
  • http://www.jsfldl.com/robots.php?root=api/ok&html=awXxo2BM
  • http://www.jsfldl.com/robots.php?root=api/ok&html=z8drKg
  • http://www.jsfldl.com/robots.php?root=api/ok&html=SDhCTHiE7
  • http://www.jsfldl.com/robots.php?root=api/ok&html=3y8W5c
  • http://www.jsfldl.com/robots.php?root=api/ok&html=GTfyKBw
  • http://www.jsfldl.com/robots.php?root=api/ok&html=LkJci8SX
  • http://www.jsfldl.com/robots.php?root=api/ok&html=mGyWjJcsl
  • http://www.jsfldl.com/robots.php?root=api/ok&html=qhVoBF
  • http://www.jsfldl.com/robots.php?root=api/ok&html=SjT8gyCD
  • http://www.jsfldl.com/robots.php?root=api/ok&html=OTiw0Sn
  • http://www.jsfldl.com/robots.php?root=api/ok&html=GyW4CQJ8
  • http://www.jsfldl.com/robots.php?root=api/ok&html=nFY04Z7M9
  • http://www.jsfldl.com/robots.php?root=api/ok&html=s1EBI07iS4
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Gov2lQfDI
  • http://www.jsfldl.com/robots.php?root=api/ok&html=k4VfNjOu
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ZEFSOg9ibl
  • http://www.jsfldl.com/robots.php?root=api/ok&html=4cp2MWOA
  • http://www.jsfldl.com/robots.php?root=api/ok&html=keTEMFln
  • http://www.jsfldl.com/robots.php?root=api/ok&html=hcZH4YxDPs
  • http://www.jsfldl.com/robots.php?root=api/ok&html=6ak08sfcn
  • http://www.jsfldl.com/robots.php?root=api/ok&html=KH1ROgP2
  • http://www.jsfldl.com/robots.php?root=api/ok&html=g3OefEGlDu
  • http://www.jsfldl.com/robots.php?root=api/ok&html=BlRVu3It5C
  • http://www.jsfldl.com/robots.php?root=api/ok&html=UA8NRwYzt1
  • http://www.jsfldl.com/robots.php?root=api/ok&html=tW3lgI
  • http://www.jsfldl.com/robots.php?root=api/ok&html=3WALv8F2r
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Gs17LC
  • http://www.jsfldl.com/robots.php?root=api/ok&html=OX4ewRhtkx
  • http://www.jsfldl.com/robots.php?root=api/ok&html=TpYKozFD
  • http://www.jsfldl.com/robots.php?root=api/ok&html=kfU3GQhXEV
  • http://www.jsfldl.com/robots.php?root=api/ok&html=m4WSJiB
  • http://www.jsfldl.com/robots.php?root=api/ok&html=bX41rFjl2x
  • http://www.jsfldl.com/robots.php?root=api/ok&html=aVTpc1
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Xrs42K9kw
  • http://www.jsfldl.com/robots.php?root=api/ok&html=H3DWsySZ
  • http://www.jsfldl.com/robots.php?root=api/ok&html=bPS5nR86i
  • http://www.jsfldl.com/robots.php?root=api/ok&html=HLCJTvdk
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ra1dWP
  • http://www.jsfldl.com/robots.php?root=api/ok&html=W0hEmJ
  • http://www.jsfldl.com/robots.php?root=api/ok&html=8vicXp
  • http://www.jsfldl.com/robots.php?root=api/ok&html=8ms74I5CwN
  • http://www.jsfldl.com/robots.php?root=api/ok&html=x9836yZd4
  • http://www.jsfldl.com/robots.php?root=api/ok&html=LGahInZPHW
  • http://www.jsfldl.com/robots.php?root=api/ok&html=FjytzkRw1
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ZEfTXFHu
  • http://www.jsfldl.com/robots.php?root=api/ok&html=2lGDsc
  • http://www.jsfldl.com/robots.php?root=api/ok&html=VHsOqDI
  • http://www.jsfldl.com/robots.php?root=api/ok&html=sRIt6Nwuoq
  • http://www.jsfldl.com/robots.php?root=api/ok&html=mfrFIthK
  • http://www.jsfldl.com/robots.php?root=api/ok&html=gj7qEoDw
  • http://www.jsfldl.com/robots.php?root=api/ok&html=C9AYWc
  • http://www.jsfldl.com/robots.php?root=api/ok&html=7dDX15C
  • http://www.jsfldl.com/robots.php?root=api/ok&html=3pzLE6r
  • http://www.jsfldl.com/robots.php?root=api/ok&html=WUbHrOj
  • http://www.jsfldl.com/robots.php?root=api/ok&html=qZREOT7rUs
  • http://www.jsfldl.com/robots.php?root=api/ok&html=YU3CwGh
  • http://www.jsfldl.com/robots.php?root=api/ok&html=o6H4CYcORP
  • http://www.jsfldl.com/robots.php?root=api/ok&html=ntWCHsXo
  • http://www.jsfldl.com/robots.php?root=api/ok&html=VrYn0CM
  • http://www.jsfldl.com/robots.php?root=api/ok&html=qxP8wG
  • http://www.jsfldl.com/robots.php?root=api/ok&html=Bmineu
  • http://www.jsfldl.com/robots.php?root=api/ok&html=THD3GdMY
  • http://www.jsfldl.com/robots.php?root=api/ok&html=KpMekW74IE
  • http://www.jsfldl.com/robots.php?root=api/ok&html=mdDSWNr2